廚房排煙那為什么需要定期清洗呢

發布人：http://www.hkcts.com.cn   發布時間：2022-12-26 18:55:09

濟南酒店廚房排煙工程在酒店、食堂中是很重要的。廚房排煙工程定期就需要清洗。那為什么需要定期清洗呢，一起來了解一下吧。
The kitchen smoke exhaust project of Jinan Hotel is very important in hotels and canteens. The kitchen smoke exhaust works need to be cleaned regularly. Why do you need to clean it regularly? Let's find out.
我們知道排煙系統是由煙罩、煙室、橫煙道、豎煙道、油煙分離凈化器、風機組成的， 煙罩位于灶臺之上，一般由不銹鋼和白鐵皮制成，下面炒菜時，油煙四處彌漫，但因為開著風機，煙霧就直接聚攏在煙罩內從吸風口進入煙室了。日久天長，煙罩上就吸附了大量的油污。油水混合物其順著煙室往廚師頭上、身上滴，嚴重時就像下雨一樣連綿不絕。這種情況是特別危險的。
We know that the smoke exhaust system is composed of a smoke hood, a smoke chamber, a horizontal flue, a vertical flue, an oil smoke separator and a fan. The smoke hood is located on the stove and is generally made of stainless steel and white iron sheet. When cooking below, the oil smoke is diffused everywhere, but because the fan is turned on, the smoke directly gathers in the smoke hood and enters the smoke chamber from the air intake. After a long time, a lot of oil stains are adsorbed on the hood. The mixture of oil and water drips onto the head and body of the chef along the smoke room. In severe cases, it is like rain. This situation is particularly dangerous.

通風位置盡可能高，是吸頂安裝，風道同樣是越短越好，減少管道阻尼噪音。依據上述要求可以保證抽油煙機和排風機工作時低噪音（噪音小于55分貝的標準）；通風換氣效果達到設計能力。
The ventilation position should be as high as possible. It should be ceiling mounted. The shorter the air duct is, the better, so as to reduce the damping noise of the pipe. According to the above requirements, it can ensure that the range hood and exhaust fan can work with low noise (the national standard of noise less than 55 decibels); The ventilation effect shall reach the design capacity.
濟南廚房排煙道的走法有5種，要看實際情況適合哪一種百了，一：在頂棚里面預埋直徑160MM的PCV管，放在煙度機設計位置的上方。第二：在吊柜頂部與廚房頂棚之間的空隙走，吊柜前面需要設計封板遮擋。知第三在煙機二層擋板后面直接走背墻，這樣的一半是別墅才能實現。第四：老式房子，沒用公用煙道的，煙機在飄窗上，煙機管走窗戶玻璃道。第五：廚房高度吊頂后低于2300，一種第二種方法無法實現，煙機管在吊柜里穿過吊柜側板進入共用煙道專。煙機煙道的的設計直接影響到煙機的排煙效果和整體廚房外觀的效果，建議采用一屬、第二種方式。
There are five ways to walk the exhaust flue in Jinan kitchen, depending on the actual situation. First, a 160mm diameter PCV pipe is embedded in the ceiling and placed above the design position of the smoke detector. Second: walk in the gap between the top of the wall cabinet and the kitchen ceiling, and the front of the wall cabinet needs to be covered by a sealing plate. Zhidi walks directly behind the second baffle of the flue gas turbine on the back wall, so that half of it can be realized by villas. Fourth: Old style houses do not use public flue. The flue gas machine is on the window, and the flue gas pipe goes through the window glass channel. Fifth: The height of the kitchen ceiling is lower than 2300, and the second method cannot be realized. The flue gas pipe enters the common flue through the side plate of the wall cabinet in the wall cabinet. The design of the flue of the flue gas turbine directly affects the smoke exhaust effect of the flue gas turbine and the overall appearance of the kitchen. It is recommended to adopt the first and second methods.
通常油煙凈化器在使用一段時間后就要進行清洗，如果油污過多就會導致里面電場阻塞，油煙凈化器無法正常進行工作，大大降低凈化效率。一旦被舉報還要面臨停產整改，增加大量額外支出，更嚴重的是萬一引發火災，就會危及到人的生命財產。
Usually, the lampblack purifier needs to be cleaned after a period of use. If there is too much oil, the electric field inside will be blocked, and the lampblack purifier cannot work normally, which greatly reduces the purification efficiency. Once reported, the company will also face shutdown rectification, which will increase a lot of additional expenses. More seriously, in case of a fire, it will endanger the safety of people's lives and property.
以上就是為大家介紹的有關濟南鐵皮風管加工的詳細的介紹,希望對您有所幫助.如果您有什么疑問的話,歡迎聯系我們.我們將以的態度,為您提供服務http://www.hkcts.com.cn
The above is a detailed introduction to the processing of Jinan iron sheet air duct, and I hope it will be helpful to you. If you have any questions, please contact us. We will provide you with our attitude http://www.hkcts.com.cn