為什么要對通風管道防腐保溫？

發布人：http://www.hkcts.com.cn   發布時間：2021-06-10 11:21:26

眾所周知，通風管道的基本用途就是送新風和排氣，將有害氣體排出室外，把室外新鮮空氣送室內。在使用安裝時需要做好防腐保溫，那這樣做有什么必要性呢？ 讓我們跟著通風管道廠家一起了解一下：

As we all know, the basic purpose of ventilation pipe is to supply fresh air and exhaust, to discharge harmful gases out of the room, to send outdoor fresh air indoors. In the use and installation of the need to do a good job of anti-corrosion insulation, then what is the need to do so? Let's follow the ventilation duct manufacturers to understand:

一般情況下使用鍍鋅鐵管，有腐蝕性及特別潮濕的場所使用不銹鋼管。當周圍環境空氣濕度較大時，風道外壁需做防腐蝕、防銹處理。對輸送高溫、高濕氣體的風道內壁宜噴刷磷化底漆或其他耐蝕涂料。在風道輸送高溫氣體或低溫空氣時，風道外壁應做保溫(保冷)處理下。

Generally, galvanized iron pipe is used, and stainless steel pipe is used in corrosive and especially humid places. When the ambient air humidity is high, the outer wall of the air duct should be treated with anti-corrosion and anti rust treatment. Phosphating primer or other corrosion-resistant coating should be sprayed on the inner wall of air duct conveying high temperature and humidity gas. When conveying high-temperature gas or low-temperature air in the air duct, the outer wall of the air duct should be insulated (cold insulation).

輸送高溫氣體風管的保溫目的，一是防止管道內空氣的熱損失(出現在冬季集中空調系統);另外是防止在輸送廢熱蒸汽或高溫氣體時阻止熱量散發到房間內而使室溫升高，又可防止人接觸風道而被燙傷。而在夏季往往因輸送氣體的溫度低于周圍環境的空氣露點溫度時，管道外壁會產生結露現象。這對集中空調系統的風道會加大冷量損失，同時凝結水滴會污染吊頂和墻地面，因此也應該進行保冷隔熱處理。

The purpose of heat preservation of air duct conveying high temperature gas is to prevent heat loss of air in the duct (in winter central air conditioning system); In addition, it can prevent the room temperature from rising due to the heat emission to the room when conveying waste heat steam or high temperature gas, and prevent people from being scalded by contacting the air duct. In summer, when the temperature of the transported gas is lower than the dew point temperature of the surrounding air, condensation will occur on the outer wall of the pipeline. This will increase the cooling loss of the air duct of the central air conditioning system, and at the same time, the condensate droplets will pollute the ceiling and the wall floor, so the cold insulation treatment should also be carried out.

上述就是通風管道防腐保溫的原因，只有進行防腐才能在之后的使用中減少腐蝕的現象，所以我們要注意這些方面，盡量保證在之后的使用中更加的順利，效果更好。

The above is the reason for the anti-corrosion and heat preservation of ventilation pipes. Only by anti-corrosion can we reduce the corrosion phenomenon in the later use, so we should pay attention to these aspects, and try our best to ensure that the later use is more smooth and the effect is better.